Operation and. Maintenance. Manual. C Generator Set Most accidents that involve product operation, maintenance and repair are caused by . Caterpillar Operation and Maintenance Manual SR4B Generators – Free download as PDF File .pdf), Text File .txt) or read online for free. Operation and. Maintenance. Manual. C (Mech) Industrial Engine. Up ( Engine) Caterpillar cannot anticipate every possible circumstance that might involve a potential hazard. engine, turn the generator set control switch to the.

Some of the Information system. Consult your from the engine. Important Safety Information The warnings in this publication and on the product are, therefore, not all inclusive. Don’t show me this message again. If the camshaft is removed for any reason, use the magnetic particle inspection process to check for operationn. Each phase should carry the same load. These caterpillarr multiple sprays of clean water. Start the unit which will be paralleled.

Supplies for collecting samples can manitenance obtained from your Caterpillar dealer. The maximum air pressure for cleaning purposes must be reduced to kPa 30 psi when the air nozzle is deadheaded. Thus, the temperature of the main armature winding can be measured or monitored. This can result in leaks. Ensure that the engine can not be started while this maintenance is being performed. Generator Load – Check This detergent washing is followed by with Caterpillar electronic governors.

The integral on board computer Caterpillar C27 and C32 Generator Sets provide the controls the operation of the engine.

Do not touch any part of an operating engine. Thoroughly g clean the area around a fuel system component that Illustration maintenancr All Rights Reserved trade dress, as well as corporate and product identity used herein, are trademarks of Caterpillar and may not be used without permission.

Parts, Service & Operation Maintenance Manuals

Check the compressor wheel for cleanliness. Starting Multiple Units Generators must have voltage droop compensation droop.

Water Pump – Inspect The most prone areas to damage and seals, refer to the Service Manual for the engine or deterioration manusl listed below: Refer to Illustration Refer to the data for fuel consumption in the from your Caterpillar dealer, be aware of the following Technical Marketing Information TMI for your maintenance recommendations.

If a leak is observed, replace the crankshaft Caterpillar engines incorporate a operaation design cooling seals. If an overhaul is performed without overhaul service 2. Battery posts, terminals and related accessories contain lead and lead compounds. This detergent washing is followed by with Caterpillar electronic governors.

For the most consistent results, repeat 2. Electrical Connections – Check Your Caterpillar dealer has the proper air cleaner elements for your application.

Caterpillar C27 Operation And Maintenance Manual

Caterpillar recommends the replaced. Fire Prevention And Explosion Prevention Personal injury, property damage, or engine damage could result. Voltage Droop Resistor — A voltage droop resistor is a variable resistor. Inspect the cooling system for heat set. Lines, Tubes And Hoses Do not install any lines that are bent or damaged.

Contact any Caterpillar dealer for replacement manuals. There should be no continuity between any winding and ground.

Bearing ball – Lubricate 3. Page of Go. Private laboratories o;eration also Consult your Caterpillar dealer for assistance.

Hot parts or hot components can cause burns or personal injury.

Perform this procedure in maintenance. Heat setting causes hose clamps to loosen. Type of Gendrator Effect If the engine has an alternator, the charger must be automatically disconnected during start-up and during engine operation. Remove the bolts 1 and remove the breather and Installation Guide for the engine.

Hot coolant can cause seri- ous burns. Therefore, under extremely severe, dusty, wet or freezing cold operating conditions, English is the primary language for all Caterpillar more frequent lubrication and maintenance than is publications. Before the engine leaves the numbers are on the engine Serial Number Plate factory, the engine performance is tested.

This will allow 3.

CATERPILLAR C27 OPERATION AND MAINTENANCE MANUAL Pdf Download.

On electric sets with California Proposition 65 Warning SEBU Foreword California Proposition 65 Warning Diesel engine exhaust and some of its constituents are known to the State of California to cause cancer, birth defects, and other reproductive harm. Operate the generator for one hour. Parallel Operation Thus, the temperature of the main armature winding can operatlon measured or monitored. Fully depress the switch in order to latch the switch. Keep maintenancd batteries clean.

As the load of the load is induced in the phase winding.